I'm Sick, Frustrated, angry, about to lose my job, what else? Powered by Discourse, best viewed with JavaScript enabled. If you get one from the salvage get them from the same car. also, check the battery. I had my foot on the brake, I was about to stop. statistics and reliability analysis of Ford Five Hundred, all problems of the 2006 Ford Five Hundred, all problems of the 2005 Ford Five Hundred, all problems of the 2007 Ford Five Hundred. This needs to be investigated immediately before something terrible happens to someone. Thanks for listening. We have since talked to several Ford dealers including Ford motor company , they all said it was our responsibility to fix the problem. Along with the first completely new full-size chassis since 1979, the 2005 Five Hundred introduced two distinct full-size model lines to Ford (for the first time since the 1978 discontinuation of the Custom 500). happened last month i chnaged throttle body and had had pcm updated still going limp and wrench light still comes. to no avail. Then instrument panel speedometer goes black, if you got the dash it comes back on the battery got completely drained bought a new one. The contact stated that the air conditioning unit failed and was blowing hot air. Ford House Said The Fuel Pump Was Bad Where Is The Fuel Pump Located In A 2000 Ford Excursion V10. Both times it cranked back up with no issues. 2005 FORD Five Hundred - Center for Auto Safety Ford Five Hundred Car Stall Problems - Carproblemzoo.com See Ford Five Hundred Vehicles With This Problem 3 model years affected 2005, 2006, 2007 Average mileage: 126,054 (1-300,000) Check Engine Light Diagnosis & Testing : $88 -$111 The average cost for a Ford Five Hundred Check Engine Light Diagnosis & Testing is between $88 -$111. This guide will show you the quickest and easiest way to rest the ECU in a Toyota. Had This Problem Approx 1 Yr Ago. and started it again. last month in January my Five Hundred had other issues. They issued memo's to their stores, (which I have copies of) but NEVER sent a letter to the owners. The approximate failure mileage was 55,000. When you change the normal fuel pump you have to change the left pump too. Having already planned to get a new vehicle in the near future, I went to the Toyota dealership the same day and left with a 4Runner. Also lost power steering, and abs breaks. My car has roughly 62,000 miles on it. I was 80 miles from home when the engine shut off. Many people's description of a defective transmission body matches our description, but that part is, apparently, on backorder. Was going to take it to the mechanic on Monday and the car just died. This has been happening every week or so for nearly a year, and no one can tell us what's wrong. Escape had not exhibited any issues going home. Faulty Crankshaft Position Sensor One of the most common reasons for the issue of car shuts off while driving is a faulty crankshaft position sensor. I have an 06 4x4 that shuts off at least 4 times a week and I have to put it in N to restart then I'm good for the rest of the day. Days lights flicker. When stopped at a light for instance the idle speed becomes low and sometimes stalls. The manufacturer was notified of the defect. Was on a busy interstate doing 70 mph and managed to get the car to the side of road on the shoulder. Park the truck nose down. brakes, steering (cant say about lights as my experiences were in the daylight only). I really feel a class action suit or recall is needed. Twice the car was running at approximately 65 mph and suddenly go into failsafe mode then stall out. I am typically not one to complain, but I feel very strongly about the safety of this vehicle, especially since I have a 3yr old daughter. When I go up and down steep hills my check battery light comes on, but once on level the light goes out. While driving all controls are lost, e.g. However, I'm not really surprised about that. It's acting like bad alternator. http://www.rockauto.com/catalog/moreinfo.php?pk=443736&cc=1431199. There was bumper to bumper traffic on a hot day. It turns out it is a faulty instrument cluster, just like the TSB mentioned. The failure recurred after the repairs. it could have resulted in the rapid spread of a fire that would quickly overtake the vehicle. I have taken in to dealership and explained these "symptoms" but they just say they don't know what it could be and will have to check it out while it is happening. ". 2005 ford five hundred. The car will just shut down all I do not think it should be my responsibility to pay for this since the part was recalled !!! no warning lights at time. Just because the check engine light isnt currently on, does NOT automatically mean there are not stored fault codes to retrieve. I can't afford repairs or a new car. Everyone basically stating the dealer gives them the run around. Guys,so maybe I'm not explaining myself quite well here so I apologize.My issue is driving down the road and my engine shuts off.I'm not talking about the engine shutting down at a stop light.Also,I always turn my start/stop off as soon as I start my truck.The alert I get on my instrument panel references the auto start/stop but I really can't . Search: 2005 Chevy Silverado Blower Motor Resistor. Ford Five Hundred owners have reported 85 I was a hundred yards away from my house and the dashboard lit up with all possible warning lights, then the engine died, and refused to turn over. They swapped it with a 2006 five hundred motor. My 2006 Ford Five Hundred is surging there's no power it stumbles shuts off. Happens running driving and sitting still. Door froze shut and ever since manually opening the message center states driver door ajar and passenger door ajar and they are not. I was in drive but foot on brake! I am always extremely cautious when there are people around when I slow down to less then 15mph or back up. After all of this car still gave check engine and wrench light and car still stalled out and had no power. The manufacturer was notified of the failures, but no solution was offered. When I Turn The Key I Here It Start And Then It Stalls Out. 2005 - 2007 Ford Five Hundred Throttle Body Problems DIY Auto Homeschool 18.7K subscribers Subscribe 1.2K Share 96K views 3 years ago In this video, we are dealing with throttle body issues on. I brought it back to where I bought it and they said computer was fried. It should never be in control of moving by itself when the brakes are applied. Of course the coverage ended on 03/31/2013. My car started chugging and running rough so I figured it was another coil. Please note that whenever the vehicle is on park and put into reverse, the higher acceleration takes place. . 2005 ford 500 shuts off while driving I have a busted motor mount and transmission mount on a 2005 Ford Five Hundred just as of yesterday here in Memphis it has started to warm up so I had my a/c on yesterday and when in operation while at slow speeds or at stop light the car will idle rough and start shutting on and off for about a millisecond. The big three used many vendors in common, and when they closed we can't get Ford parts made. It wouldn't start again. this has happened to many Ford Five Hundred owners! The contact stated that at times when the vehicle was stopped at a traffic light, it would accelerate slowly upon take-off. Any warning lightscheck engine lightsanything? Car shutting off while driving - Mustang6G by racingrush Wed Nov 03, 2010 3:59 am, Post - YouTube No start! Do Not Sell or Share My Personal Information, 2006 F150 5.4 Sputtering - New thread CONDENSED, https://www.morepowertuning.com/how-to-idle-relearn. While driving 60 mph, the vehicle failed to accelerate and the power train wrench icon illuminated. Its free and only takes a minute, Return to 2000-2007 Ford Taurus & Mercury Sable (4th Generation), Powered by phpBB Forum Software phpBB Limited. If this is happening to Explorers, Freestyles, Mustangs and many other makes and models maybe the throttle body assembly was made by the same mfg. I was going to have the car towed, but I was told by a mechanic that he cannot diagnose the problem unless the warning lights ieengine are on. Would not start, had towed to mechanic. 2006 Ford Mustang Shuts Off While Driving? Recalls need to be put into place before someone dies! When this happens the reverse lights come on even when in drive. Vehicle then began showing random warning lights including "check engine", which was diagnosed first time as low fuel level sensors a & b. Would start up but could not go over 10 miles per hour. The Ford dealership drove it and ran diagnostics on it for weeks at a time and found nothing to tell them anything. bumpy road ) its now done it 5 times, Ford looked at it once and drove it for 20 miles, said they couldnt recreate the problem, has anyone experianced anything of . by tmac1180 Mon Nov 01, 2010 7:14 pm, Post Wednesday, December 12th, 2012 AT 7:47 PM. FORD FIVE HUNDRED OWNER'S MANUAL Pdf Download | ManualsLib all problems of the 2006 Ford Five Hundred If I am on the freeway running 70 mph, get off the ramp and the engine stalls. Used a different key next day, drove to work,home & out to run errands. Our harness is an upgraded, direct replacement for the GM 15862656 and the AC Delco PT2195. While driving dash lights, speedometer, tachometer, gas level, and temperature go out for several minutes at a time. My daily drive is turnpike 70 mph. The vehicle was taken to an independent mechanic for diagnosis where the vacuum operative valve behind the throttle body was replaced. The vehicle was taken to a dealer where it was diagnosed that the electronic throttle body sensor failed . The problem might be with a defective crankshaft position sensor. Drove for approx 10 miles and then it started running rough again and appeared to be losing power. The dealer cannot figure out what is causing the battery to drain. The previous two other times I was going full speed on the freeway, when the engine just shut-off. The approximate failure mileage was a 139,000. All I could think about was to move over into the right lane and get off the road somehow. Oil was present in the engine and no other major issues seemed to be present before this one. I got back in the car turned the ignition and after a few seconds it started and I could tell it was only running on 4 cylinders instead of 6. And that will cause a big wreck and maybe kill myself or worst someone else. We have since talked to several Ford dealers including Ford motor company , they all said it was our responsibility to fix the problem. I was on freeway and could have been severely injured if I was hit. 2005 ford: five hundred that stalls..scanned..few seconds..dies I Have A 2003 Ford Explorer Sport Trac Xls. The mechanic stated that the transmission needed top be replaced. Instrument cluster not working. The contact owns a 2005 Ford Five Hundred. The length of time of time it took for the fuse to finally blow is quite alarming! The Fora platform includes forum software by XenForo. In July the engine misfired several times on a 400 mile trip. Now driving back to normal. An employee of the store that was on the back, left side of the car pointed towards and said, look! Expect the throttle body needs to be replaced but don't want to spend any more money on "diagnostics" when Ford knows this is a problem part and they need to stand behind it!!!!! Car stalls while driving. I reported it to Ford, and got a nice complaint number. If you shop at Amazon.com (for anything), use this link to support FordTaurus.net! But I can't reset driver controls until doors show closed. After reading these comments, I fear driving it, if it starts. I bought from original owner, low mileage (they upgraded). However, the car was still running. wrench light comes on while im driving i turn car off start it back up starts fine. The car is essentially un-drivable, because we cannot count on it to get to us work on time or safely. The contact stated while driving approximately 30 mph, the vehicle became inoperable unable to shift into gear. It will surge forward when turning into a parking spot and in many other instances. The crankshaft position sensor's role is monitoring the engine's many moving parts including the crankshaft, engine valves, and pistons. Proceeded back onto highway for about 2 miles. The contact was able to shut off and restart the vehicle in order to operate normally. The contact owns a 2005 Ford Five Hundred. The contact coasted the vehicle to the side of the road, turned it off and restarted it. I own a 2005 Ford Five Hundred there was a recall in 2012 on the throttle body, a Ford dealer supposably cleaned the throttle body, well now its not driveable. The failure mileage was 100,000. . the car could stall at anytime while driving putting myself and my family at risk, I don't think much of this automobile company for not standing behind there product, I will never recommend a Ford vehicle to friends,family or even my worst enemy never never again!!!!. You must be able to get it stopped on the side of the road and shut the car off and then restart it to correct the problem for a short period of time. I can fix the ford 500 at 4 days of replacing parts and research I added throttle body and sensor, gas pedal, map sensor, fuel rail sensor, plugs, intake gasket, egr, removed the entire exhaust system and removed the inside of the converter in front of the muffler and made sure exhaust was totally clear, new fuel filter, new fuel pump. Consumer stated the left front head light caught on fire spontaneously while having been parked for 30 minutes in the garage and engine was off. The contact owns a 2005 Ford Five Hundred. Wont shift from first gear after cluster panel shuts off. Signal lights melted and quit working. Instrument cluster shuts off intermittently while driving - YourMechanic I could have killed someone. One restarted it returned to normal but the wrench icon light was on the dash. I was almost sold on Ford until recently when I was with my family in my 2005 Ford Explorer. The most common reasons a car shuts off while driving are a bad crankshaft position sensor or fuel supply problems. I can't keep buying and replacing coils on this thing since it's not paid off and in my bankruptcy I can't trade it in either. I then pull over wait for 10 seconds to 2 min and it starts back up. When I am in park or neutral my motor makes a ticking noise. About a month later, I was coming home from WalMart and was at a stop when the car cut off. The batteries on overage only last around 2 years. Morning after I installed pump, started & shut off again. Driving Procedure: Release pressure in the fuel tank by removing and re-installing fuel cap. It has recurred a few times, its most noticeable after dark as dash lights go black. Unfortunately the junk yards want $200 for the cable and didn't want to do that. This is dangerous and should be an electrical recall. This has happened about 7 times now. problems related to car stall (under the engine and engine cooling category). Other times, it would not work at all. I called her and had her send the part over at HER PRICING of $820 total. You cant steer, you cant brake!!! I always have to be extra careful. Add another to the list. statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. My car is fine and then I go to start the car it won't start. Changing the fuse fixed the problem. If it comes on, try to only start the truck while cluster is on. in this instance with the loss of power steering and no one was hurt or even killed due to their little " known problem " that they seem to have conveniently put on the " back burner " for the public ( their customers and REPEAT customers ) to shell out bucks due to their obvious PARTS FAILURES over and over. Car Won't Start When I Turn The Key I Here It Start And Then It Stalls Out. We thought is may have been the gas. Have run code in my car and only code is p0193 fuel rail pressure sensor. The contact owns a 2005 Ford Five Hundred. See we love it. The contact stated that the vehicle stalled without warning while driving 30 mph. Without much confidence, they returned the car to me and said they could not replicate the problem. Code is p0191, replaced fuel pump and inertia switch as suggested in tsb. 4.6L) 2011-2014 V6 Mustang Pre-2005 V6 Mustang . was told by a mechanic that he cannot diagnose the problem unless . While driving approximately 70 mph, all of the gauges on the instrument cluster stopped functioning and displayed readings of zero. Stalled out while at low rpm and would not restart. The contact continued to drive and the instrument cluster began working a few moments later. Out of Fuel. Had throttle body replaced still had similar problems progressing little did I know when throttle body is replaced has to be reprogrammed by Ford! Cpsc: i1390188a. This fixed the car and have no issues or lights. Im afraid for the safety of my fellow drivers on the at night . This is dangerous; unable to tell speed! The Engine Will Turn Over But It Will 1994 Motorhome Fuel Pump In Tank Is Bad. I had to pull over and shut the car off. Waited 2 min. What Do You Have Any Suggestions To Help Figure Out Why 2005 F150 With 4.2l 6 Cyl 2wd Will Not Start. I am very good to my car so now what. It is completely random and you never know when or if it will happen. Ford its time to step up and do a recall!!!!. this is on a 2007 Ford 500, low miles. Yesterday, while I was driving the engine shut off, and the dashboard stated to look at gauges. This is the third time that this has happened. The vehicle will lunge out even when the brake is pressed. The VIN was unavailable. all problems of the 2006 Ford Five Hundred How to ditch your carrrrr. Me and my seven year old daughter was in the car. While driving the dash board goes dead and all of the gauges go to zero. The vehicle that I have is a 2005 Ford F-150 4x4 with a 5.4 litre engine. The RES control will not work if the CNCL vehicle speed is not faster than 30 mph (48 km/h). Kw. by Cuda_jim Wed Nov 03, 2010 10:50 am, Post Once again..$120 EACH or about $750 at their prices. The vehicle would then stall once the message was displayed and would not restart. The contact merged the vehicle to the shoulder, turned the engine on and off and the vehicle started immediately. Cost $1800. problems related to electrical system (under the electrical system category). We don't sell/share your email. They said it was bad ignition coil packs. The contact stated that while driving 70 mph, the wrench warning indicator illuminated as the vehicle stalled. You need to get a new cluster and replace the old one. Service Engine light then came on and so I got it started again and took it immediately to the nearest auto shop. An estimate for me was $900 from my mechanic. Engine light, oil light and something else came on. 2. I have also noticed a mechanical smell coming from the ac. Your Focus's engine needs three things to run properly; air, fuel, and spark. The vehicle was not further repaired. So now I'm still paying the loan on it while it sits in shop waiting for the part. I see someone already pointed out no recall on this problem. Tl-the contact owns a 2005 Ford Five Hundred. The cluster will turn off ( tac, speedo, gas guage, ect ) Then all the warning lights will come on at the same time and stay light up ( 4x4, abs, engine, parking brake ect ) The odometer will just be blank ( it is still lit up but no mileage is shown ) Tac, speedo, and all my gauges look as if the truck is off Please issue a recall on the instrument panel replacement. back to engine Complaints 2K Crash Tests 3 Recalls 5. After doing an online review I noticed that many other Ford Five Hundred owners having the same issue and seems to be caused by "throttle body". This problem may be covered under warranty. This is dangerous as it almost caused an accident by jerking backward immediately when I shifted to reverse when I was in the parking lot- my foot was on the brake and the car still excelled. However, none of these parts are available due to being on backorder. See Follow directions how to clear failsafe and implement them. theft light killing car randomly - Ford Truck Enthusiasts Forums Engine Shutdown While Driving 2005 Ford Escape (Page 1 of 2) This problem may be covered under warranty. In case Ford needs good reason to do recall how does I fear driving after stalling no warning on freeway and have 3 people almost hit me on Tuesday at 130pm 8/5/14 check ktvu bay area news see what traffic was like yep could have been killed. 2005 Ford Five Hundred Engine Stopped Running While Driving. HELP To restart, must shut car off, key out and it will restart. well 2-3 months later I get it to crank with a phone call from a mechanic I paid to call, and boom my brand new ignition coil pops up in smoke under the hood. In this case, it's usually fuel. While driving about two weeks ago, the little wrench light came on and I lost power. Gauges drop check engine light comes on then wrench light then one shaped like a car n starts loosen power. Unable to restart. A service station diagnosed the problem and found an electrical short in a computer module which controls the radiator fan. Shutting off while driving! Ford should have a recall on this issue! I have also found numerous other complaints on various blogs, forums, and other sites. What was upsetting is that this is a common problem for this year of Escapes. The suv was towed to my mechanic. It has happened while slowing into a parking space, backing up, pulling away from stopping at a light or stop sign. . I am having this repaired at the moment. The manufacturer was not made aware of the issue. I had my air conditioner on and we were only traveling at 5-10 mph. Can I Just Install A Fuel Pump Outside The Tank? Get notified about new defects, investigations, recalls & lawsuits for the. . CK Engine light came on and started flashing. I had to carpool for about a week, and the warranty did not cover the problem. I had no warning was in bad traffic from a collision just up ahead when the car just died. Inside the cover are two large. The fuel pump fuse had a crack in it. So, OPTION B.spend $200 for the used cable, let the Ford tech. Upon initial inspection I fount the car was throwing the code p0351 I cleared all faults and problem went away weks went by and problem started again but more sever during normal operation the car started shaking and shifting erratic I then came upon some k formation as to a recall Ford put in place stating improper calibration of pcm and tcm cause unnecessary interaction I the electrical system and malfunction of the vehicle. I had already replaced 2 coils at 300 a whack. Yesterday the check engine light came back, and the car was running poorly (creeping when first off brakes, not up shifting), when the dash was operable it showed alternating check engine/check transmission warnings, and vehicle was surging/lagging noticeably at highway speeds. 2005 Ford F150 Starter Fuse LocationFord F-250 / F-350 / F-450 / F-550 Ford should at least offer the computer at a discount. DANGEROUS!!! Luckily there were no other cars near me. I had no where to turn off, no power steering, and very little braking power. It started back up and ran fine. When shopping for a new suv I likely won't even consider a Ford. Find solutions to your toyota ecu reset procedure question.